Editing Z31/Overheating php (section)

=== Common Overheating Issues ===

-
Is the radiator clear of debris?

Road debris, leaves, dirt, and even dead bugs can clog the front or rear of your radiator. When the fins are blocked, airflow is reduced, lowering the radiator’s ability to transfer heat and keep your engine cool. Inspect the radiator regularly—especially if you drive in dusty or leafy environments.

If you notice buildup, carefully rinse the radiator fins from the rear (engine side) with '''low-pressure water'''. Avoid using high pressure, as it can bend or damage the delicate fins, further restricting airflow.

Tip: Check for trapped debris between the radiator and AC condenser as well! -
Does your thermostat work?

The thermostat controls coolant flow from the engine to the radiator. If it gets stuck closed, coolant cannot circulate, and your engine can overheat quickly, no matter the weather or driving speed.

'''Symptoms of a stuck thermostat:''' Engine heats up rapidly, the upper radiator hose stays cold, and the heater may not blow hot air.

If in doubt, replace the thermostat with a high-quality or OEM part—it’s a cheap and simple fix for many cooling problems. -
Does the car overheat at low speeds (e.g., in traffic)?

Overheating while idling or at low speeds is usually due to insufficient airflow or air trapped in the cooling system.- Cooling Fan Clutch/Operation: If your Z31 uses a clutch fan, the clutch can wear out, causing the fan to spin too slowly and move less air at idle. For electric fans, check that the fan turns on when hot. If not, check fuses, relays, or the fan motor.
* Air in the System: Trapped air can prevent coolant from circulating properly. To bleed the system, start with a cold engine and radiator cap off. Let the engine warm up to operating temp, and watch for air bubbles in the filler neck. Top off the coolant as air escapes, and continue until no more bubbles appear.

-
Does the car overheat at high speeds only?

If your temperature rises only at highway speeds or under hard acceleration, you may have a '''clogged radiator''', restricted cooling passages, or internal scaling. At speed, the water pump circulates coolant faster, but if there’s blockage, it can’t absorb or shed enough heat.

Try a thorough cooling system flush with a quality flush solution, following manufacturer instructions. If your radiator is old or severely clogged with minerals, replacement or professional cleaning is often necessary.

Did you know? Hard water and old coolant cause scale, which insulates metal and drastically reduces cooling efficiency. -
Other possible causes:

* Low coolant level: Check for leaks and top off as needed.
* Old or worn water pump: Impellers can corrode or lose effectiveness over time.
* Loose or slipping belts: The water pump may not be spinning fast enough.
* Radiator cap failure: A bad cap won’t maintain system pressure, leading to boil-over and overheating.
* Collapsed hoses: Old, soft hoses can collapse and restrict coolant flow, especially under high RPMs.

-
Quick Summary Table:
Symptom Most Likely Cause Quick Fix Overheats at idle/traffic Fan not working, air in system Check/replace fan clutch or electric fan, bleed air Overheats at speed Clogged radiator or scaling Flush or replace radiator Engine heats rapidly from cold Stuck thermostat Replace thermostat Coolant loss Leaks, bad cap, blown head gasket Check hoses, cap, and for white smoke